Another type of electric assist motor, often referred to as the mid-drive system, is increasing in popularity. With this system, the electric motor is not built into the wheel but is usually mounted near (often under) the bottom bracket shell. In more typical configurations, a cog or wheel on the motor drives a belt or chain that engages with a pulley or sprocket fixed to one of the arms of the bicycle's crankset. Thus the propulsion is provided at the pedals rather than at the wheel, being eventually applied to the wheel via the bicycle's standard drive train.
This article first appeared in Electric Bike Report in June of 2013. Since then, we’ve made some changes to our motor selection - our Direct-Drive motors are now all High-Torque 6x9 wound, so they run slower (approximately 15mph at 36v or 20mph at 48v), and our Geared Motors have been replaced by a 500w version, (approximately 20mph at 36v or 28mph at 48v). The Direct-Drive is now our Heavy-Duty motor and the...
Controllers for brushless motors: E-bikes require high initial torque and therefore models that use brushless motors typically have Hall sensor commutation for speed and angle measurement. An electronic controller provides assistance as a function of the sensor inputs, the vehicle speed and the required force. The controllers generally allow input by means of potentiometer or Hall Effect twist grip (or thumb-operated lever throttle), closed-loop speed control for precise speed regulation, protection logic for over-voltage, over-current and thermal protection. Bikes with a pedal assist function typically have a disc on the crank shaft featuring a ring of magnets coupled with a Hall sensor giving rise to a series of pulses, the frequency of which is proportional to pedaling speed. The controller uses pulse width modulation to regulate the power to the motor. Sometimes support is provided for regenerative braking but infrequent braking and the low mass of bicycles limits recovered energy. An implementation is described in an application note for a 200 W, 24 V Brushless DC (BLDC) motor.[43]
This past July 1st we moved our location to Croydon, PA and doubled our space. Additionally we're looking to hire at least 2 additional employees! This is all to support our expanding conversion kit business and to support some new business we have planned starting in September (more to come on that soon). We would like to thank every single one of our customers, partners, associates and fans for your...
Yes, there are less expensive ebikes on the market but most come with a few serious caveats. The Espin Sport delivers on the full promise of an electric bike, but in a more affordable fashion. This bike isn’t going to tow you around for a 60-mile round-trip endeavor but those seeking their first ebike will get plenty of return on their investment with this model.
Government agencies like the USDA National Forests and the Bureau of Land Management should distinguish between electric pedal-assist eBikes (Type 1) and self-propelled eBikes (Type 2). The former are still human-powered whereas the latter are fully motorized like a motorcycle. Some states like California are already recognizing the different classifications of eBikes and allowing some on trails while prohibiting others. This clear distinction should help us avoid expanding our mountain bike trails to motorcycles, or worse yet, have trails that are currently open to mountain bikes relegated to “hiking only.”
Up to today we have been offering up to 500W of power for those that need this extra umph depneding on rider weight or terraine but now with up to 1000W soon configurable from our hope page you will have the power you need to handle any situation. Tow loads with Stark Drive, leave the car at home and use pure electric power to bring home your groceries from your local market. Take your kids with you wherever you would like with a cargo carrier.
Electric Bike Parts, what fits my older electric bike? What can I modify to fit my bike? A brief overview of what electric bike parts do, and how generic electric bike parts can be adapted to your bike. The Plugs, Wires & Connectors Hardly a day goes by without a call that goes about like this; "I have a (whatever) electric bike that I used to ride 6 years ago....

All models of the Turbo Levo use a frame made from M5 aluminum alloy, with the motor and removable battery integrated inside. The frame and fork use 148mm (rear) and 110mm (front) spacing. Specialized 6Fattie Purgatory (front) and Ground Control (rear) 3-inch wide tires are laced to 38mm Roval Traverse rims. Rear stays and pivots are beefed up to handle the additional weight (48.5 lbs) and torque, and bridges are added to the stays, over the non-motorized Stumpjumper. The front fork is a RockShox Yari XC with a 15mm thru-axle. The 135mm rear travel is provided by a custom Fox Float Performance DPS shock with automatic sag adjust. 
Yukon Trails Outback Electric Mountain Bike is an affordable urban bike with a 24 volt motor of 250 watts. The lead-acid battery of 10 AH offers 28 miles in a charge. This mountain bike is manufactured in China. The bike has the solid tires of 1.75 Watt and 24 inches. It reaches up to the speed of 15 MPH due to the rim of 24 inches. You can smoothly ride the bike while enjoying the fresh air. The seat is comfortable to sit for a long time.
As the weather begins to drop and the snow starts to fall, it is increasingly important to know how to properly care for your electric bike and its Lithium-ion battery. It may be possible for some people to ride their bikes during the winter months, while others must pack them away until the warmer weather returns. Whether you plan to ride in the cold and snow or if you decide to...

Cyclocross demands a lot from both bike and rider, and the CruX has been engineered to give the precise and efficient performance needed to win races, and the durability to win them every weekend. The frame's geometry and character has been created with input from some of the world's most accomplished racers, making for an agile, easy-to-shoulder bike that is as fun to ride in a World Cup as it is in the local woods.

Many years of experience have clearly shown that it isn’t possible to make a universal and realistic estimate of an ebike’s range. The range of an eMTB depends on countless factors such as the support level, terrain, rider weight, environmental conditions, and cadence. Those who demand a lot of power from the motor consume a lot of electricity. If you want to travel far, you’ll have to save battery power. Read more about this topic in our article The truth about lab tests.
All models of the Turbo Levo use a frame made from M5 aluminum alloy, with the motor and removable battery integrated inside. The frame and fork use 148mm (rear) and 110mm (front) spacing. Specialized 6Fattie Purgatory (front) and Ground Control (rear) 3-inch wide tires are laced to 38mm Roval Traverse rims. Rear stays and pivots are beefed up to handle the additional weight (48.5 lbs) and torque, and bridges are added to the stays, over the non-motorized Stumpjumper. The front fork is a RockShox Yari XC with a 15mm thru-axle. The 135mm rear travel is provided by a custom Fox Float Performance DPS shock with automatic sag adjust. 
With mountain bikes already sporting hefty price tags, the cost of adding an electric motor might be enough to send the value-conscious rider's head spinning. Fear not! We created the table below to help you sort through which bike has the best performance to price ratio. Bikes that fall lower and further to the right, such as the Top Pick winning Commencal Meta Power Race 650B+ and the Haibike XDURO AllMtn 8.0 represent a relatively great value.
I used to mountain bike quite a lot. I was a fairly strong 17 stone (238lb) weightlifter and rode pretty fast but didn't go in for big air or jumps. Nevertheless I used to break bikes at a ridiculous rate. I broke the bottom bracket off a Marin titanium frame, I broke the bottom bracket off of a Roberts hand built mountain bike. I snapped 2 pairs of handlebars, broke cranks, pedals, chains, wheels, spokes and forks etc etc.

Mountain bikers and their associations (which I used to be a proud member of), should reconsider their anti-eMTB stance, realize there is a need and demand for Type 1 eMTBs, and focus their efforts on keeping trails open for all mountain bikes. Mountain bikers deserve the right to ride more of our public trails than we are currently allowed. I won’t open a can of worms with my strong opinions on where I believe mountain bikes should be allowed, but suffice it to say that we don’t have near enough access as we should.

…but currently offer only very few advantages, such as a cleaner design and the option to mount a bottle cage in a front triangle. If you want to take a spare battery in your backpack, you will have to struggle with the larger dimensions of the integrated batteries, or you won’t have the possibility to take one with you at all. Depending on the integration, handling the integrated rechargeable battery (e.g. the on-button for Shimano-Intube) can be awkward. Also, the longer battery results in a higher centre of gravity. The fact is that there are good reasons for continuing to use a standard external battery.


In full-electric mode, the Pedego City Commuter Classic Electric Bike is capable of moving at up to 20 mph for anywhere from 15 to 30 miles. There are two further options: power-assisted pedaling or fully "unplugged” riding. Renowned Shimano gears are easy to select. Seldom do we come across a product so universally praised by owners. It's not cheap, but comments like "Everything I hoped for!" and "Outstanding!" tell us that it's money well spent.
I'm looking to leverage the Cycle to Work Scheme and have been looking around for an e-bike to purchase. I used a lot of the information provided here and have come to the conclusion that the Kreiger from Woosh meets all my needs. 95% of the time the bike will be used to commute to and from work, the rest of the time I'll probably be rising it around the park with the kids. The thing I like about this bike is that it pretty much comes with everything (except the lock) that you'd need to get going. I guess, if I really wanted to, I could upgrade the Bafang motor on this to a BBS02 with a better battery.
Two years worth of research and development may seem like a long time for a mountain bike but when you take a closer look at what Rogue Ridge accomplished in that time period we’re confident you’ll appreciate the work. For instance, each offering hosts a best-in-class 1000-watt motor and 13 amp hour battery to help keep this electric fat bike at the ready whenever you are. Also, with said set of fat tires, any terrain from sand to mud; rocks to snow, is within your grasp. Additional features include a full-color digital display, a range of 29 miles without pedaling, and a tech welded 6061 aluminum alloy frame among many others.
After doing some research, I found that the article was correct: the US Forest Service and Bureau of Land Management both prohibit eBikes on their trails that allow mountain bikes. In the eyes of these national agencies, eBikes are “motor vehicles” and lumped in with motorcycles, ATVs, and even off-road vehicles like Jeeps. I have been riding knobby-tired motorcycles since I was in third grade and can clearly state that pedal-assist eMTBs and “dirt bikes” are completely different animals.

Those are our choices for the top eMTBs this year. There are loads of great options as battery life continues to improve and motors provide more assistance than ever before. Electric bikes are primed to move heavily this year. It’s the only bike market that continues to grow every year. The more units that sell, the better the bikes become. That’s great for consumers and the bike community in general!
REBEL electric bikes powered by the Yamaha central motor create Dynamic and Responsive Power. It also enables the use of a conventional groupset and offers no resistance in «no assistance» mode. The eMTB bikes range have an “External DT System” battery, located in the front triangle and integrated with the design of the frame. The relative position of the less lightweight parts of the system (motor and battery) enables a low center of gravity, guaranteeing a reactive and stable ebike. See the REBEL electric bike models...
Descents on such a heavy bike are less fun. Getting the rear wheel off the ground on short notice, or whipping it around turns is very hard. I like to use my rear tire and brakes to steer—locking the brakes in tight corners at speed, then letting off and pedaling out. On very loose and exposed trails, using that approach on the Turbo Levo doesn't work, once the rear starts to loose traction, it’s just all over. Perhaps this could be combated with lower rear tire pressures; we were running 20 PSI. 
Shell Eco-Marathon Americas Competition 2014 1st and 2nd Place Winners Both Used an Electric Bike Technologies Hub Motor! The Mater Dei Supermileage Team of Mater Dei High School, in Evansville, Ind., took the top spot in the Prototype category. The team built a vehicle using an electric bike motor from Electric Bike Technologies USA and won the electric plug in class at the 2012 Shell Eco Marathon Americas.  They raised the...
The time or distance an electric bike battery will run between chargings is impossible to judge with much accuracy. There are too many variables: terrain, speed, rider weight, bike load (shopping, kids, luggage), and more. However, we can make a few generalizations about an e-bike’s recharge time and overall working life. These generalizations should be used for comparison purposes only.
Motor: We have a blog post showing some motor differences: https://www.ebikekit.com/blogs/news/its-whats-inside-your-motor-that-counts Cabling is probably the #1 issue when something goes wrong. Good connectors, good cables, and good assembly (bike shop!) are crucial Strain reliefs on all cable joints! Where you have a junction box or a connector, the stress is concentrated over a small area near this stiff spot on the cable. This can cause small breaks on the internal...
Tackle your daily commute with ease or go for a weekend cruise in style with the Gazelle CityZen T10 e-bike. And don’t worry about those thigh-burning hills; the Bosch motor offers four assist levels—Eco, Tour, Range Sport, Turbo—making hills a breeze and the Lithium-Ion battery provides a range of up to 85 miles in Eco mode. The bike is one of the first to use Bosch's new integrated battery, which is concealed in the downtube. The matte black paint and classic, step-through design give a classic look while fenders, pannier racks, and integrated lights add practical functionality. The bike is easy to maneuver in city streets, but still has assist up to 28mph so you can cover a lot of miles and power up steep hills. There's a suspension fork too. It's not at the level of something you'd find on a mountain bike (or even some better e-bikes) but it takes the edge of some potholes and curbs.
The Ancheer folding electric mountain bike does have a few weird quirks. The first is the handlebar mounted battery. It saves space for the folding mechanism, but looks odd. Fortunately it has very little effect on handling because it is mounted so close the head tube’s pivot point. It does raise the center of gravity of the bike a bit, but the difference is small compared to how much you raise the bike’s center of gravity.

Electric Bike Conversion Kit Systems Now Available from one of USA’s Leading IBD Distributors Philadelphia, PA: Electric Bike Technologies USA, a manufacturer specializing in affordable high-quality electric bicycle conversion kits, announced that their EBikeKit ™ and E-TrikeKit™ systems are now available via J&B Importers. With J&B’s extensive network of authorized dealers, the conversion kit products will now be readily available throughout the country at most local bicycle shops. Of the...

The Liv Amiti-E+2 is a low-priced but highly versatile e-bike. It’s just as much at home on the pavement as it is on bike paths and rail trails. But don't feel constrained to groomed paths. Front suspension and 42mm-wide tires mean you can take on off-road detour on your way home from work. Speaking of work, this e-bike makes a great commuter thanks to rack and fender mounts and integrated lights for riding after dark. Internal cable routing and a nicely integrated battery make for clean lines and 9-speed shifters give you plenty of gearing options for whichever type of terrain you decide to tackle. This do-everything bike is great option if you’re riding includes a little bit of this and a little bit of that.

This is a question the designers and engineers of the FOCUS and BULLS bikes of this group test asked themselves. Instead of speccing them with the standard 500 Wh batteries, both have developed a sophisticated alternative. The idea: instead of riding around with unnecessarily large batteries and unnecessary weight on short tours, they integrated a smaller 375 Wh or 378 Wh battery into the bike. If you don’t have enough power for long loops, you can double the range of both bikes with an additional battery for up to a full 750 Wh. While the second battery is mounted in the front triangle of the FOCUS, it disappears sideways in the downtube of the BULLS. In practice, you’ll need the second battery relatively often with both bikes, and in either case, you should consider the additional € 499 investment in a second battery pack when you buy the bike.


There are two main types of motor to suit different riding styles. The durable, "heavy duty" Direct-Drive motor, and the lightweight, efficient and fast "performance" geared motor. Electric Bike Motors, hub motors in particular, and electric bike batteries are what make electric bicycles go. Using a hand throttle you control the flow of electric current from the battery to the brushless motor. With an intelligent 20 Amp controller regulating the...
I'm looking to leverage the Cycle to Work Scheme and have been looking around for an e-bike to purchase. I used a lot of the information provided here and have come to the conclusion that the Kreiger from Woosh meets all my needs. 95% of the time the bike will be used to commute to and from work, the rest of the time I'll probably be rising it around the park with the kids. The thing I like about this bike is that it pretty much comes with everything (except the lock) that you'd need to get going. I guess, if I really wanted to, I could upgrade the Bafang motor on this to a BBS02 with a better battery.
The Shiv TT boasts an aerodynamic frame that observes the letter, but not the spirit, of the UCI's laws on position and frame shapes. Its profile has been refined in our Win Tunnel to take crosswinds in stride, and the wide range of fit options in the integrated cockpit lets riders find a fast, comfortable position for putting out power. Impressively, this is done without causing time-eating instability in tight corners or on technical descents.
What exactly is an electric bike? How can they be used for transportation and why do they make financial sense? These are some of the questions my site http://electricbikereview.com and this channel aim to help you answer. This particular video provides an overview of the Easy Motion Neo Jumper ebike and then follows me on an actual commute to work in Austin Texas.
Adam Boesel, inventor of the UpCycle Ecocharger, is using Electric Bike Tech hub motors and working with GM and Chevrolet to build bicycle generators featured at the 2015 Pan Amercian Games!   Adam Boesel is using Electric Bike Technologies hub motors on bicycles that generate electricity! Now General Motors has taken his idea to the 2015 Pan American Games and is using them to show people how PLAY can literally...
While the first functional battery was developed in the year 1800 by Italian physicist Alessandro Volta, a practical battery would not be seen for several decades yet. By the end of the 19th century, practical and portable batteries were more widely available, this finally freeing the electric motor to be used in a wide new array of applications. It might come as a surprise, but the electric motor, battery, and a bicycle were first paired as far back as the 1890s. It would be approximately 100 years later that electric bicycle development finally entered the mainstream, but the technology and concept behind the electric bike were all in place generations ago.
Commencal has only just recently entered the electric mountain bike market, and their Meta Power Race 650B+ is a well designed and hard-charging contender, the winner of our Top Pick for Aggressive Riders Award. Commencal has integrated the Shimano Steps E8000 pedal assist motor into their proven Meta frame design, creating a bike that climbs well and also charges downhill. This bike comes to life at speed downhill thanks to a progressive long and slack geometry and a great component spec which is highlighted by a stout Rock Shox Lyrik fork and a plush Super Deluxe Coil rear shock. The Meta Power Race took top honors for its climbing performance, mostly due to the Shimano Steps E8000's consistent power output and extended power band, and testers also loved its e-bike controls, with an ergonomic shifter, best-in-test digital display, and user-friendly charging connection.
The bike is great but you have to pedal it has no throttle it's a pedal assist. When you put the power on and Start to pedal the power kicks in the motor stops if you stop pedaling.it has 3 power modes the low is pretty much useless unless you are in a crowded place I used it on full power it's fast my phone app show 19 miles it was a flat surface but I am 160 pounds.and really easy to pedal.the seller did a great job the first bike I received was defective the front wheel axle was bent so they send me another bike after I return the defective bike bother shipping was free so great on their part I Haven't use this bike long the only issue I had is you have to adjust the front disk brake if you are handy or take it ... full review
I always felt GM should have taken a similar strategy as IBM did. Get rid of the manufacturing and focus on the service. In IBM’s case, it was a logical choice. But for a carmaker, switching to service only is foreign territory. GM has a lot of might in its manufacturing power and its global presence, now streamlined to a few brands. However, most of its sales are still gasoline SUVs, CUVs, and pickup trucks, as with other major OEMs. How much is it really focusing on its electric mobility path, including the addition of folding electric bicycles?
Atom ebikes are characterized by their "TS System" patented by BH Bikes, which integrates the battery in the diagonal tube, enabling the shape of a traditional frame. Its optimized design offers compact geometry characteristics. The 2019 e-MTB range incorporates the Boost 148x12 rear axle and high-end peripherals. The Trekking e-bike range integrates; high performance lights, racks, saddles and grips that meet the needs of our most demanding riders. The 2.8” LCD color display with USB port incorporates a new remote control in the 2019 range. see the ATOM eMTB bikes...
Cape Fear Community College students are utilizing the E-BikeKit™ electric bike kit in the designing and building of their own electric bicycles!   ORIGINAL ARTICLE POSTED by the Port City Daily staff "CFCC student-built electric bikes to be in Azalea Fest parade Some innovative designs by Cape Fear Community College students will be featured in this year’s N.C. Azalea Festival. For the past year, students in CFCC’s mechanical engineering program have been hard...
It’s not as far-fetched as it sounds. In Europe, where the e-bike market has exploded, the European Cycling Union announced that it will create a new racing circuit for e-bikes, including e-road and e-mountain bikes, for the 2019 season. Following suit, the UCI said it will include an electric mountain bike competition in the 2019 World Mountain Bike Championships. Yes, there will be a rainbow jersey awarded to the world’s best off-road e-biker.
In order to make the final judgement of every bike as objective as possible, the test team includes ex-racers and engineers as well as amateur riders and eMTB newbies. Even if we explored the bikes’ performance on the trail to the limit, we attach as much importance to their everyday usability. A potent and balanced bike which shines on demanding singletrack and is fun to ride should ride just as well on more moderate trails. And even if you’re not taking yourself and your bike to the limit every time you ride, it’s good to know that the bike is prepared for any situation you might feel like throwing at it.

After 2 months of online research and talking to people that owned e-bikes I walked into the Glendale, Arizona Pedego store. I met the owners Sherry and Steve. They suggested I try the Ridge Rider as it might be a fit for me. I test rode it for about 45 minutes to an hour and was somewhat convinced this could be the bike for me. I went home and did more research on the Ridge Rider. After careful thought I decided to purchase one the next day. Since then Steve, the owner, has worked with me to personalize my bike so that it is as comfortable on the trails as it is on the road. I cannot say enough about the after sale experience I have received from Sherry and Steve. I would recommend them and their store to anyone interested in an e-bike.


We are an independent third party from Square, Inc. and Square Capital, LLC. All loans are issued by Square Capital, LLC,. a wholly owned subsidiary of Square, Inc., d/b/a Square Capital of California, LLC in FL, GA, MT, and NY. Loans are available in select states. Square and the Square logo are trademarks of Square, Inc. Other trademarks and brands are the property of their respective owners.

Controllers for brushed motors: Brushed motors are also used in e-bikes but are becoming less common due to their intrinsic lower efficiency. Controllers for brushed motors however are much simpler and cheaper due to the fact they don't require hall sensor feedback and are typically designed to be open-loop controllers. Some controllers can handle multiple voltages.
×